Kubota Utility Vehicles

Kubota RTV500 parts – New and Aftermarket

Kubota RTV500 Parts

When looking for parts, its is often a good idea to try and obtain a copy of a pdf manual as well.

When buying parts for the Kubota RTV500, it is a good idea if possible to have the chassis number of the vehicle, as well as being able to be as specific as possible as to which part is actually required.

This will help to track the part, and also help in locating a manual if needed which will contain diagrams for Kubota RTV500 parts, and greatly help in being able to fit them properly.

Below are two different breakdowns of what parts may be available.

The first part is a breakdown of part by category, the second is a breakdown of parts by more specific motor or mechanical usage.

Some of these categories also applied to a range of Kubota Tractors, which are often used in conjunction with the Kubota RTV500.

Category 1

3 Point Linkage / Drawbar/ Hitch – Kubota RTV500 parts

  • Lift Rod  LH
  • Lift Rod  RH
  • Lower link
  • PTO shaft protector
  • Stabiliser
  • Swinging drawbar
  • Top link
  • Top link bracket

Air Conditioner – Kubota RTV500 parts

  • Air conditioning duct
  • Air conditioner hose
  • Compressor
  • Condenser
  • Dashboard air outlets
  • Heater hose
  • Inner air recirculation
  • Mode case

Accessories and Service parts

Brake parts

  • Brake
  • Brake pedal
  • Brake rod
  • Parking brake lever

Cabin Parts

  • Cab Bracket front
  • Cab Bracket rear
  • Cab Frame
  • Door LH
  • Doorlock LH
  • Door lock RH
  • Sender
  • Fender cover
  • Floor mat
  • Front glass
  • Hood rear
  • Inner  roof
  • Near window
  • Rear view mirror
  • Seat
  • Side window
  • Toolbox

Canopy

Cargo and Storage Accessories

Chassis parts

Clutch parts

  • Center frame
  • Bevel gear
  • Clutch release fork
  • Clutch rod
  • Differential rear
  • Driveshaft
  • First shaft
  • Input shaft
  • PTO clutch
  • PTO clutch valve
  • PTO propellor shaft
  • PTO shaft
  • Rear axle case
  • Second shaft
  • Shift cover
  • Shuttle dear case
  • Shuttle shaft
  • Transmission case
  • Clutch
  • Clutch lever
  • Clutch pedal
  • Clutch housing

Cooling System parts

  • Radiator
  • Shutter
  • Fan
  • Reserve tank
  • Water pipe

Cylinder Head

Electrical system parts

  • Battery
  • Alternator
  • Dynamo
  • Dynamo and van
  • Light
  • Regulator and meter
  • Electrical wiring
  • Hazard light/tail light touch
  • Head light
  • Panel board/switch
  • Starter
  • Switch
  • Stop solenoid
  • Tail light
  • Working light
  • Switch/sensor

Engine parts

  • Accelerator lever
  • Air cleaner
  • Alternator
  • Camshaft and idle gear shaft
  • Cover
  • Crankcase
  • Cylinder head
  • Dipstick and guide
  • Exhaust manifold
  • Fan
  • Flywheel
  • Fuel camshaft
  • Gear case
  • Governor
  • Head cover
  • Idle apparatus
  • Injection pump
  • Inlet manifold
  • Lower gasket kit
  • Main bearing case
  • Muffler
  • Nozzle holder
  • Oil filter
  • Oil pump
  • Oil switch/thermometer
  • Piston and crankshaft
  • Speed control plate
  • Starter
  • Stop solenoid
  • Kubota kit
  • Valve and rocker arm
  • Water flange and thermostat
  • Water pump

Engine control parts

Filters and Maintenance

Frame Parts

Front axle parts

  • Differential gear shaft
  • Bevel gear case
  • Knuckle shaft
  • Engine support
  • Front axle
  • Front axle case
  • Front differential
  • Front differential case
  • Front drive shaft
  • Front frame
  • Subframe

Fuel Sytem Parts

  • Fuel pipe
  • Fuel filler
  • Sedimenter
  • Separator
  • Fuel filter
  • Fuel tank

Hood / Bonnet – ROPS Parts

  • Bonnet
  • Bonnet side
  • Center pillar
  • Floor sheet
  • Main frame
  • Shutter plate
  • Side cover
  • Fender
  • Front grille support
  • Lever guide
  • Manual holder
  • Panel frame
  • ROPS
  • Seat
  • Street support
  • Step
  • Step stay

Hitch and Drawbar

  • Drawbar and hitch
  • PTO shaft protector

Hydraulic system parts

  • 3 point linkage
  • Control valve
  • Cylinder front cover
  • Draft control valve
  • Feedback lever
  • Hydraulic oil line
  • Hydraulic cylinder
  • Hydraulic pump
  • Lift arm
  • Position control lever
  • Top link bracket

Ignition Parts

Paint and Trim Parts

Pump Motor System

  • Control valve
  • 3 point linkage
  • Feedback lever
  • Oil tank
  • Position control lever
  • PTO valve
  • Safety valve
  • Hydraulic control lever
  • Hydraulic cylinder
  • Hydraulic oil line/delivery
  • Hydraulic line/steering
  • Hydraulic piston/lift arm
  • Hydraulic pump
  • Hydraulic pump/component parts

Rear axle parts

  • Differential lock pedal
  • Rear axle
  • Rear differential
  • Rear wheel
  • Spiral bevel pinion

Rear PTO parts

Section part

Speed Change Lever

  • Differential lock shift fork
  • Frontwheel drive lever
  • Main gear shift fork
  • Main gear shift lever
  • PTO gear shift arm
  • PTO gear shift fork
  • PTO gear shift lever
  • PTO select lever
  • Range gear shift fork
  • Range gear shift lever
  • Speed control pedal

Steering parts

  • Steering controller
  • Steering cylinder/component parts
  • Steering handle
  • Manual steering
  • Steering linkage
  • Steering post
  • Tilt pedal

Top Link / Top Link Bracket / PTO Protector – Kubota RTV500 parts

  • Lift Rod
  • 3 point linkage
  • Check chain
  • Hitch
  • Lower link
  • Mower rear link LH
  • Mower rear link RH
  • PTO protector
  • Top link
  • Top link bracket
  • Toys and Merchandise

Transmission parts – Kubota RTV500 parts

  • Clutch shaft/output shaft
  • Front wheel propeller shaft
  • Countershaft
  • Main shaft
  • PTO counter shaft
  • Reverse shaft
  • Forward idle shaft
  • GP idle shaft
  • HST one – cylinder block
  • HST two/arm
  • HST 3/port block cover
  • HST 4/oil cooler cover
  • HST fan cover
  • Mid PTO
  • Propeller shaft
  • PTO shaft
  • Rear gear shaft
  • Rear axle case
  • Rear differential
  • Transmission case

Wheel –

Category 2

Kubota RTV500 Parts

Filters and maintenance – Kubota RTV500 parts

  • Air filter
  • Engine oil filter
  • Extended life antifreeze/coolant
  • Filter maintenance kit
  • Fuel filter – in line
  • High-performance agricultural/construction equipment grease
  • Hydraulic oil filter
  • Hydraulic suction oil filter
  • Lever action grease gun
  • Engine oil
  • Gear lubricant
  • Synthetic universal hydraulic fluid

Cylinder head and component parts – Kubota RTV500 parts

  • Complete cylinder head
  • Exhaust valve guide
  • Inlet valve guide

Gauges and Instruments – Kubota RTV500 parts

  • Temperature gauge

Ignition parts – Kubota RTV500 parts

  • Glow plug
  • Starter switch and key

Transmission parts – Kubota RTV500 parts

  • HST Damper
  • Universal joint assembly

Electrical – Kubota RTV500 parts

  • Alternator
  • Fuel shutoff solenoid
  • Hazard lamp
  • Headlight assembly
  • Headlight lens
  • Keys
  • Kubota battery
  • Oil pressure switch
  • Re-manufactured starter
  • Safety switch, seat
  • Starter assembly
  • Starter switch and keys
  • Tail lamp
  • Timer relay
  • Turn Signal Lamp

Accessories and options – Kubota RTV500 parts

  • Mascot Mark
  • Steering wheel spinnerKubota RTV 900 parts
  • Trim

Engine gaskets and gasket kits – Kubota RTV500 parts

  • Gasket kit – upper

Tires and wheels – Kubota RTV500 parts

  • Tire Repair Kit

Operators compartment – Kubota RTV500 parts

  • Lever guide – RH
  • Lever guide and cup holder LH

Mower Deck Parts – Kubota RTV500 parts

  • Dial Cam

Exhaust system parts – Kubota RTV500 parts

  • Exhaust manifold
  • Exhaust manifold gasket

Cooling System Parts – Kubota RTV500 parts

  • Cooling fan
  • Fan belt
  • Lower radiator hose
  • Radiator
  • Radiator screen
  • Thermostat
  • Apart radiator hose
  • Water pump
  • Water pump gasket

Fuel system parts – Kubota RTV500 parts

  • Fuel cap – gasoline
  • Fuel shutoff solenoid
  • Re-manufactured injection pump

lubrication systems – Kubota RTV500 parts

  • Oil pump
  • Oil pump gaskets

Steering and axles – Kubota RTV500 parts

  • Steering wheel
  • Steering wheel cap

3 Point Hitch Parts – Kubota RTV500 parts

  • 3 Point category1 lower lift arm
  • Category one top link
  • Check chain assembly
  • Clevis assembly
  • lynch pin
  • Turnbuckle

Toys and Merchandise – Kubota RTV500 parts

  • Kubota license plate
  • Kubota mechanics gloves

FAQ

Kubota RTV500 Parts

Kubota RTV500 Parts Diagram

Kubota RTV500 Aftermarket Parts

Kubota RTV500 Parts Manual PDF

Kubota RTV500 Rear Axle Parts

Kubota RTV500 Transmission Parts

Kubota RTV500 Engine Parts

 

 

Kubota RTV1100 Parts – New and Aftermarket

Kubota RTV1100 Parts

It is unlikely many people buy the Kubota RTV1100 for its looks, which are often described as making it look like an upmarket golfing cart.

This description does a disservice to what is a highly effective utility vehicle, that has a significant following and where there is a large user market. Continue reading

Kubota L3301 : Specs, Parts, Attachments, Reviews

Kubota L3301

Intro – The  Kubota L3301 was first manufactured some six or seven years ago, but has proved highly popular in today’s agricultural market, and are still regarded as one of the strongest performers that Kubota have in its range of agricultural machines. Continue reading

KUBOTA RTV1100 : Specs, Parts, Attachments, Reviews

Kubota RTV 1100

The Kubota RTV 1100 is one of the bestselling atvs on the market, and Kubota have invested much of their tractor technology into improving its level of performance.

Kubota realised that many of their competitors used engineering and mechanical models that were similar to those used in golf carts and four wheel drives. Continue reading

Kubota RTV 900 : Specs, Parts, Attachments, Reviews

Kubota RTV 900

The Kubota RTV 900 has been around since 2006, and is one of Kubota’s bestselling range of vehicles, and an acknowledged leader in the field of utility vehicles. Each model since the original has been improved in one area or another, and the current RTV-X900 is at the top of its class in terms of safety and performance. Continue reading

Kubota Side by Side

Kubota Side by Side

A Kubota side-by-side refers to a utility vehicle that is used by many agricultural and the farm operators for a wide priority of differing manual and loading jobs. It is sometimes referred to as a utility terrain vehicle, or a recreational off-highway vehicle. Continue reading

Kubota RTV Utility Vehicles – New and Used

Kubota Rtv’s are utility vehicles that come in three different shapes and sizes – compact to mid size, full size, and xg. All utility vehicles can be used for awide variety of jobs and work. Many people use them for residential purposes, different types of construction projects,  a wide range of  agricultural work. Continue reading

KUBOTA RTV CREDIT

Buying or leasing a Kubota rtv will inevitably involve some type of credit arrangement, and getting a quote  from Kubota credit can be a useful starting point, in order to compare terms and conditions with other quotes from other financial institutions such as a bank or a credit union.

It is important to understand the principles of leasing an RTV in order to be able to make a valid comparison, both with other financial quotes, and with the costs that would be involved in buying a Kubota rtv outright.

Leasing an rtv is similar in many ways to a long-term rental.

A credit lease is a legal document that wi to effectively take ownership of the Kubota rtv for a fixed period of time, normally a number of months up to  several years.

The customer will pay a monthly charge to kubota or Kubota credit over the period of the lease.

The customer will also pay a down payment at the outset of the lease, and also what is known as a lease end payment when the term of the lease expires.

There are also likely to be costs incurred relating to the condition  of the Kubota rtv when it is effectively handed back in at the end of the lease.

The customer is responsible for the condition or state of the rtv during the term of the lease, and will be expected to make good any excessive wear or tear which will be assessed once the lease has finished.

KUBOTA RTV CREDIT

At the end of the lease, it is quite likely that the customer will be given an opportunity to purchase the rtv outright, and depending upon their circumstances this may or may not make financial sense.

If the customer receives a financial offer of credit from Kubota / Kubota Credit  or any other financial institution, such an offer may be dependent on  a cosigner of the lease.

This normally happens either when the person taking out a credit arrangement is  quite young, and the cosigner is either a parent or guardian, or where the applicant’s credit history is either poor or unproven.

In any event, if a cosigner is required it is important to realise that they assume joint financial responsibility with the applicant for all financial terms and conditions that are specified in the lease.